Gravity Always Wins ( Ladders) Tool Box Talk
Gravity never forgets. As soon as you set foot on the ladder’s first rung and pull your body off the ground, gravity works to bring you back to earth. Therefore, it’s no surprise that ladder safety begins from the ground up.
Start With A Good Foundation
Proper ladder setup will help prevent slips and falls. Place the base on a firm, solid surface. Avoid slippery, wet or soft surfaces. If you must put the ladder on a soft surface, place a board under the ladder’s feet to provide a firm footing. Make sure the top of the ladder has a firm support as well.
Never lean a ladder against a window pane or other unstable surface. If you’re using a straight or extension ladder, the angle of the ladder is the next critical safety factor. A straight or extension ladder should be placed 1 foot away from the surface it rest against for every 4 feet of ladder height. For example, if the ladder if 4 feet high the bottom of the ladder should be 1 foot away from the support surface.
If you use a ladder to access a roof or platform, make sure the ladder extends at least 3 feet over the roof or platform edge. Be sure to securely fasten straight and extension ladders to the upper support. If you have angled the ladder properly and still have doubts about its stability, have someone hold the ladder before climbing up.
If you’re using a step ladder, be sure to open it completely up before you climb. If you have to use a step ladder near a doorway, lock or barricade the door nd post signs so no one will open it and knock you off the ladder.
Climb With Care
When you climb, always face the ladder and grip the rungs of the ladder to climb, not the side rails. Never get on or off a ladder from the side unless it has been secured to prevent movement.
Never climb with equipment in your hands. Use your pocket, equipment belt, or a tool pouch and raise heavy objects with a hand line. If you forget something, always climb down the ladder to retrieve it yourself; don’t have someone toss it up to you. And never ask someone to climb up your ladder to give you supplies. It is dangerous to exceed the weight limits that a specific ladder can handle.
When you descend a ladder, practice the same safety rules. Face the ladder, keep your body square and hold on to the rungs. Lastly, step off at the bottom rung of the ladder. Never jump off of a ladder.
Think Before You Carry
Before you start to haul a ladder around, evaluate the area where you’ll be working. Ladders can be heavy and unwieldy. You can strike another person or object, or hit electrical power lines. Make the ladder as compact as possible before transporting it. Carry it horizontally while tilting it higher in front and lower in the back. If the adder is particularly long and heavy, get a coworker to help you carry it.
Follow The Rules
Ladder safety may seem simple, but injuries occur every year. Below are some ladder safety dos and don’ts:
- Use the right ladder for the job.
- Inspect the ladder before and after a job.
- Read all warning labels carefully and follow directions before you climb.
- Clean the ladder after each use to prevent dirt buildup.
- Wear clean, dry, slip-resistant shoes and use ladders with slip resistant feet.
- Don’t stand any higher than the third rung from the top of the ladder.
- Don’t lean too far or overreach. Reposition the ladder close to the work instead.
- Don’t use a ladder as a bridge or scaffold.
- Don’t put a ladder on a box, barrel or other object to gain additional height.
- Don’t use a damaged or unsafe ladder.
Experts also warn about ladder use in bad weather. Descend immediately if high winds, rain or other inclement weather begins. Wind force can blow you off the ladder. Rain can make the rungs and the ground slippery. Bitter cold can make ladders more brittle and can cause other structural damage. If you encounter bad weather while on a ladder, do not speed up to finish the job and risk injury. Wait to finish the job until conditions are once again safe.
SAFETY REMINDER – DONT LET GRAVITY GET YOU DOWN. PRACTICE LADDER SAFETY RULES EVERYTIME YOU CLIMB TO MAKE YOUR WORK EASIER, FASTER AND SAFER.